Since most other threads on the “new” Model S refresh (as of early 2021) are busy discussing the most obvious changes to the interior, I thought the advancements to the battery cells and pack architecture deserved a separate thread of its own.
What we know for sure:
1. Per the shareholder deck posted on Tesla’s investor relations site, the “both the battery pack and modules have now been fully redesigned” (see page 9)
2. During the earnings call conducted on January 27th 2021, Elon mentioned that “the new S currently uses the 18650 form factor, they're just a more advanced cell” while answering analyst Alex Potter of Piper Sandler.
3. The Model S product page on Tesla’s site mentions “new module and pack thermal architecture allows faster changing and gives you more power and endurance in all conditions”, and that “both Long Range and Plaid powertrains, with update battery architecture, are capable of back-to-back, consistent 1/4 mile runs”.
What we think is most likely the case:
The existing 18650 format only applies to the Long Range and Plaid variants, while the Plaid+ that was announced at the end of the Battery Day presentation on September 22nd 2020 will use the new 4680 format cells, which provide even more power and more range.
What we don’t know for sure yet:
1. Total and usable capacity of the new packs; the Long Range gained about 10 EPA rate miles over the previous version, but with the new models including a heat pump, the more efficient motors from Model 3/Y, and a decently lower drag coefficient, shouldn’t the gain in range be higher assuming the pack didn’t change in capacity? Could it be that the new pack has less capacity, especially given the ~250 lbs weight loss between old & new Long Range models?
2. Supercharging taper curve; after what SoC does the 250kW peak start to drop off, and how fast? From the Model S product page, Tesla mentions 200 miles gained in 15 minutes, which is just under half the capacity given the 412-mile range. So perhaps ~45 kWh in 15 minutes, which is 180 kW average power for that duration?
3. Is the new Model S pack structural, as presented on Battery Day? If so, are the cells grouped closer together and to the center of the car, allowing for better handling?
Discuss, please!
PS: Elon mentioned he would do a separate presentation on the new aspects of the refresh, but I haven’t read anywhere when that will be. If you know, please share!
What we know for sure:
1. Per the shareholder deck posted on Tesla’s investor relations site, the “both the battery pack and modules have now been fully redesigned” (see page 9)
2. During the earnings call conducted on January 27th 2021, Elon mentioned that “the new S currently uses the 18650 form factor, they're just a more advanced cell” while answering analyst Alex Potter of Piper Sandler.
3. The Model S product page on Tesla’s site mentions “new module and pack thermal architecture allows faster changing and gives you more power and endurance in all conditions”, and that “both Long Range and Plaid powertrains, with update battery architecture, are capable of back-to-back, consistent 1/4 mile runs”.
What we think is most likely the case:
The existing 18650 format only applies to the Long Range and Plaid variants, while the Plaid+ that was announced at the end of the Battery Day presentation on September 22nd 2020 will use the new 4680 format cells, which provide even more power and more range.
What we don’t know for sure yet:
1. Total and usable capacity of the new packs; the Long Range gained about 10 EPA rate miles over the previous version, but with the new models including a heat pump, the more efficient motors from Model 3/Y, and a decently lower drag coefficient, shouldn’t the gain in range be higher assuming the pack didn’t change in capacity? Could it be that the new pack has less capacity, especially given the ~250 lbs weight loss between old & new Long Range models?
2. Supercharging taper curve; after what SoC does the 250kW peak start to drop off, and how fast? From the Model S product page, Tesla mentions 200 miles gained in 15 minutes, which is just under half the capacity given the 412-mile range. So perhaps ~45 kWh in 15 minutes, which is 180 kW average power for that duration?
3. Is the new Model S pack structural, as presented on Battery Day? If so, are the cells grouped closer together and to the center of the car, allowing for better handling?
Discuss, please!
PS: Elon mentioned he would do a separate presentation on the new aspects of the refresh, but I haven’t read anywhere when that will be. If you know, please share!